Vauxhall Owners Network Forum banner

Discussions Showcase Albums Media Media Comments Tags

1-20 of 62 Results
  1. Large Vauxhalls
    Hi all, New to the forums. I've read every scrap about stuck EGR valves on here. Mine is no different. It's as if some divine force wants it to stay fastened on! I've tried prising, chiseling, swearing and ragging at it. I bought a blow torch but the small flame turns into a flamethrower...
  2. Small/Medium Vauxhall Cars Area
    I have a 1.6l 2014 diesel Vauxhall Meriva and back in February I had the "Real Emissions Software Update" put onto my car. Days later, my engine light came on and and was diagnosed as an EGR flow issue. To me, this seemed like it was highly likely that the software update had caused this issue...
  3. Small/Medium Vauxhall Cars Area
    I'm currently in the process of replacing the EGR value on my 1.7 CDTI - it was well and truly stuck open, and due to the sealed design of the EGR unit it's basically impossible to clean once that happens. I've got hold of the replacement and all of the necessary gaskets for the exhaust/intake...
  4. Vauxhall Vans, Minibuses & Campervans Area
    Hello all, New vivaro owner and first time forum user. I recently purchased a 2004 1.9ctdi vivaro. Before purchase it's had reconditioned gearbox, reconditioned turbo, new exhaust manifold gasket, timing belt and water pump kit, full service and mot. After 2 weeks of ownership I noticed it...
  5. OPCOM
    Hi there, I've been having a problem with twitching/surging while driving at 1500-2000 rpm for a while now. The pressure regulator has already been changed and there are no pressure problems (according to live data from opcom). But what caught my attention is the EGR position sensor. It also...
  6. Small/Medium Vauxhall Cars Area
    Hi, does anyone know if the Meriva B Petrol 1.4 Ecotec Turbo has an EGV? At least I can't see it anywhere unless it is underneath the car but would suppose it is before the cat, which I think it is not unless it is int he turbo assy. Probably not then. M
  7. Small/Medium Vauxhall Cars Area
    Hi there, I have a 2004 Astra G Mk4 1.6 Petrol. I've been having problems with the EGR valve for a while now. At first the engine was misfiring so after a bit of searching I tried a blanking plate with two smaller holes in, this is so it limits the gas coming into the engine as the valve was...
    egr
  8. Small/Medium Vauxhall Cars Area
    For a couple of months I've felt my Meriva has been down on power at low revs, and especially when cold. It seems that significantly more power starts to appear at about 2000 RPM. Using the pedal test I got error code 0571, but no service light. On one long drive the service light came on...
  9. Small/Medium Vauxhall Cars Area
    I'm looking for the pin functions for component Y56 could someone help me with this one??
  10. Small/Medium Vauxhall Cars Area
    Hey guys. I have a 1.6 diesel astra ecoflex. I’m having trouble with my EGR intake. Iv been told to blocked off or delete my EGR, just wondering if anyone on here has done it, and is it worth doing?
    egr
  11. Egr

    Small/Medium Vauxhall Cars Area
    Hey guys. I have a 17 plate Astra ecoflex 1.6 diesel. My engine light has been on and off for over a month. Every time my friend plugs his diagnostic machine in, it comes up “low air flow on egr intake” he’s tried egr cleaner and a regene on my car but the light still comes on. Any suggestions...
    egr
  12. Car Audio / Electrical / Security / Diagnostic Rel
    I have a Zafira B (2008) with the Z16EX1 engine (75K miles). I had problems symptomatic of the EGR channels being blocked (hesitation in gear at low RPM, engine warning light coming on associated with a fault code P0171- system too lean). I have now cleaned the channels (they were badly...
  13. SUV & 4WD Vauxhalls
    Hi I am after some advice on my frontera b 2.2 2002 I have fault codes p0400 & p0243, egr valve & boost solonid a I have replaced both of these parts as well as a new turbo & maf sensors but can't seem to cure the problem All the vac pipe have no splits or damaged & have full vacume If anyone...
  14. Vauxhall Vans, Minibuses & Campervans Area
    Just bought a Vauxhall Vivaro van .. worked perfectly for 5 days short journeys and a long trip from Leeds to Whitby and back. randomly one morning the van started fine set off and after 2 minutes it just cut out ... tried to start again and it wouldn't start dash was showing battery light...
  15. Small/Medium Vauxhall Cars Area
    Hi everyone, this is my first post on this forum. Sorry for the length of this post, but I felt it was important to give a detailed history of what has happened. Sorry if the terminology is not quite right. I have a 2015 Opel Zafira diesel (1.7 CDTI 110 CH FAP Edition), Current mileage 70,000...
  16. Small/Medium Vauxhall Cars Area
    Hi All I've just bitten the bullet to swap out the EGR valve on our 2009 Meriva 1.3 CDTi. (What a PITA that was!). The good news is that my EML is now off. The bad news is I think I broke or failed to connect something properly as I have two issues: 1. A 'wooshing' sound under heavy...
  17. Small/Medium Vauxhall Cars Area
    Vauxhall Astra 2011 1.7 tdi. Does shunting/loosing power then gains back quickly, no pattern to it happening, it can go a week without doing it then be really bad. It has cut out completely on 2 hills. It had a new egr valve a couple of months ago but still have exact same issues. Diagnostics...
  18. Small/Medium Vauxhall Cars Area
    Hi Recently attempted to clean my egr on my insignia, however I have stripped the top one, Anyone know where I can purchase the screws that hold the egr. ( I think they were t25/27 screws) As I need the car regularly and cannot take the screws out and have the car off the road. any help would...
  19. Vauxhall Vans, Minibuses & Campervans Area
    Hi guys, Somebody damaged my 2007 van recently by smashing the window and snipping 2 pieces from my engine loom (why i don't know). Anyway i went to a scrap yard and picked up the same section from a Primastar of the same year only when i went to connect it all i then realized the wires are...
  20. Small/Medium Vauxhall Cars Area
    afternoon all. hoping you can help me . I have a vauxhall zafria 1.6 design 2010.im trying to locate the egr valve, but unable to find . have attached 2 photos of where I thoughg it would be and what euro carparts are sayingineed.
1-20 of 62 Results
Top